A study of diabatic distillation in a column with a low pressure drop : научное издание

Voinov Nikolai A.; Zemtsov Denis A.; Deryagina Nina V.; Bogatkova Anastasiya V.; Zhukova Olga P.

Дополнительные ссылки: eLibrary

База данных: Каталог библиотеки СФУ

Библиографическое описание: A study of diabatic distillation in a column with a low pressure drop : научное издание / Nikolai A. Voinov, Denis A. Zemtsov, Nina V. Deryagina [et al.]. - Текст : непосредственный // Chemical Engineering Research and Design. - 2022. - Т. 185, № . - P. 1-13. - ISSN 0263-8762. - ISSN 1744-3563, DOI 10.1016/j.cherd.2022.06.033.

Аннотация: This paper examines diabatic columns with a new type of tray. The design provides effective liquid reflux flow in each column tray and a low pressure drop. The contact devices comprise a stack of multi-diameter plates with raised edges. The vertical tubes of the dephlegmator integrated into the column centre pass across all plates, and are used for heat removal. Vapors of the ascending mixture partially condense onto the plate surfaces and the dephlegmator, resulting in vapor enrichment. The liquid flow down the column forms a thin layer on the surfaces of the middle and bottom plates. When the condensate drops onto the smaller-diameter top tray, it partially evaporates, is then mixed with the liquid flow on the underlying plates, and partially evaporates again. An algorithm calculation of distillation parameters for a diabatic column, with a known reflux flow rate, vapor velocity and heat transfer coefficient, is proposed and approbated. The column separation efficiency is assessed depending on the temperature and cooling-water flow rate in the dephlegmator pipe. Several approaches for enhancing the heat transfer intensity in the column dephlegmator pipe were analysed. Several heat removal methods, including liquid film flow cooling of the inner dephlegmator pipe surface, were examined. Experimental tests were carried out using an ethanol-water binary mixture and a raw spirit complex mixture. Comparison of the characteristics of the new diabatic unit and a packed column with a spiral prismatic packing showed that the plate column with the same separation efficiency has a lower pressure drop and metal consumption. The results encourage further research on this new diabatic column design.

Год издания: 2022

Авторы: Voinov Nikolai A. , Zemtsov Denis A. , Deryagina Nina V. , Bogatkova Anastasiya V. , Zhukova Olga P.

Издательство: Institute of Chemical Engineers

Источник: Chemical Engineering Research and Design

Выпуск: Т. 185

Номера страниц: 1-13

Держатель оригинала документа: Reshetnev Siberian State University of Science and Technology, 31 Krasnoyarsky Rabochy Av., Krasnoyarsk 660037, the Russian Federation

Количество экземпляров:

Твёрдая копия издания отсутствует в фонде библиотеки

Показать дополнительные сведения

A micromechanical pressure sensor with reconfigurable ASIC : статья из журнала

Tulaev A. T. и др.
2025 год

Features of Interaction of Molecular Oxygen with Condensation Surface in Low-Pressure Arc… : статья из журнала

Karpov I.V. и др.
2022 год

Biosynthesis of Poly(3-Hydroxybutyrate-co-3-Hydroxyhexanoate) with a High 3-Hydroxyhexanoate… : статья из журнала

Mohd Fadzil Fakhrul Ikhma и др.
2021 год

Development of a dual-loop method of intelligent traffic light control based on reinforcement… : статья из журнала

Sazanov A. M. и др.
2025 год

Features of Interaction of Molecular Oxygen with Condensation Surface in Low-Pressure Arc Discharge… : научное издание

Karpov I.V. и др.
2022 год

Comprehensive Study of the Efficiency of Low-Concentration Nanoemulsions with Diesel Fuel for… : научное издание

Minakov Andrey и др.
2025 год

Technological solutions for rock breaking with ejection of abrasive particles into a pressure… : статья из журнала

Shkaruba N.A. и др.
2021 год

Experimental Study on Rapeseed Drying Characteristics with Magnesium Sulfate as Solid Desiccant : научное издание

Fomenko Elena V. и др.
2025 год

Microfibrillated Cellulose with a Lower Degree of Polymerization; Synthesis via Sulfuric Acid… : научное издание

Malyar Yuriy N. и др.
2023 год

Study of the flow structure and hydraulic pressure losses in a well with a retrievable core receiver : научное издание

Zhigarev V.A. и др.
2018 год

Analytical techniques to recognize inclusion complexes formation involving monoterpenes and… : научное издание

Santana D.V.S. и др.
2021 год

A Computational Study of Cuttings Transport in a Horizontal Well with an Oil-Based Drilling Fluid… : научное издание

Zhigarev V.A. и др.
2024 год

Sulfation of agarose with ammonium sulfamate: A combined experimental and theoretical study : научное издание

Kazachenko Аleksandr S. и др.
2023 год

Study of phase composition of CuO/Cu2O nanoparticles produced in the plasma of a low-pressure arc… : статья из журнала

Fedorov L.Y. и др.
2018 год

Low pH Stress Enhances Gluconic Acid Accumulation with Enzymatic Hydrolysate as Feedstock Using… : научное издание

Dai Lin и др.
2023 год

Study of stability of low-concentration nanoemulsions of diesel fuel in water with different non… : научное издание

Stebeleva Olesya P. и др.
2025 год

Библиотечно-издательский комплекс СФУ

A study of diabatic distillation in a column with a low pressure drop : научное издание
статья из журнала

Похожие публикации